Repair Scouring Holes, Ozark Lock & Dam No. 12, James W. Trimble Lock & Dam No. 13, & Dardanelle Lock & Dam No. 10, McClellan-Kerr Arkansas River Navigation System (MKARNS)
Pre-solicitation Notice W9127S-14-R-0004: This solicitation will be advertised as an unrestricted procurement. The North American Industrial Classification System (NAICS) Code is 238110 (Poured Concrete Foundation and Structure Contractors). The small business size standard is $14,000,000.00. The solicitation is for a firm fixed priced construction contract to repair the scouring holes utilizing the preplaced aggregate methodology at Ozark Lock & Dam No. 12, James W. Trimble Lock & Dam No. 13, and Dardanelle Lock & Dam No. 10. The work includes repair of eroded concrete, in the wet, in the following areas; end sill on the lock wall side, stilling basin near the lock wall, lock wall (river side) from the intersection of the lock wall and end sill and downstream. Due to complex geometries, the only cost efficient concrete repair is accomplished using the placement method of preplaced-aggregate. This includes, but is not limited to, the following processes: existing concrete surfaces to which preplaced-aggregate concrete will bond should be thoroughly cleaned and all deteriorated concrete removed, as well as the removal of any exposed, embedded reinforcement and debris in the void; anchoring and placement of additional reinforcement into sound concrete; placement of coarse aggregate within the eroded area; erection and anchoring of water-tight formwork with adequate grout and vent pipes; design of the grout to be used in the repair; mixing and pumping of grout into the voids of the preplaced coarse aggregate; cure and finish of concrete repair; use of divers and/or acoustical imaging to verify repair results; cleanup of site, and incidental related work. The Mangnitude of Construction is between $1,000,000 & $5,000,000.
Solicitation will be issued as a Request for Proposal (RFP) utilizing FAR 15. Proposals will be evaluated utilizing the Lowest Price Technically Acceptable (LPTA) method. This solicitation will be issued via Internet only at the Army's Single Face to Industry Website (ASFI) on or about 6/16/14. It is each offeror's responsibility to download the solicitation from the internet website. No paper copies will be provided. Notification of amendments shall be made via the Internet as well. It is therefore the contractor's responsibility to check the ASFI website daily for any posted changes to this solicitation. Contractors may view and/or download this solicitation and all amendments from the Internet after solicitation issuance at the following Internet address:
https://acquisition.army.mil/asfi/solicitation_search_form.cfm and search for Solicitation Number W9127S14R0004
All offerors are encouraged to visit the Army's Single Face to Industry Website at https://acquisition.army.mil/asfi to view other business opportunities. Offerors must be registered with the System for Award Management (SAM), in order to receive a Government contract award. To register, the SAM Internet address is: http://www.sam.gov. The contract specialist for this solicitation will be Marcus Mitchell. All questions or comments should be forwarded in writing by fax at (501)324-5196 or by e-mail to [email protected].
Marcus Mitchell, 501-340-1253
USACE District, Little Rock
